The SaniPLUS is a system that is used to install a complete bathroom up to 15 feet below the sewer line, or even up to 150 feet away from a soil stack. The SaniPLUS pump is designed to connect with:
This SaniPLUS Upflush Toilet
The SaniPLUS is simplicity itself to install; there are just four connections.
The macerating/pump is connected to the spigot of a horizontal outlet toilet.
The toilet tank is connected to the water supply.
The macerating/pump is connected to the small diameter discharge pipe work.
The macerating/pump is connected to the electrical supply.
Then optionally connect the discharge pipes from the sink, shower and/or bath.
The inside of the SaniPLUS comprises of a pressure chamber, which starts and stops the unit, and the motor, which drives the stainless steel macerator blades and the pump.
When the flush is activated, the water flowing into the SaniPLUS activates a microswitch in the pressure chamber, which in turn starts the motor. The motor is sealed for life in oil filled enclosure. A common spindle drives the impeller and the macerator blades. The moving parts therefore are kept to an absolute minimum. Water and organic waste matter, enter the chamber and are reduced to slurry as the macerator blades rotate at 3600 RPM. The centrifugal force causes the reduced solids to be ejected through a grill into the container where it is picked up by the impeller pump mounted beneath the motor. The pump operates at 10 PSI and pumps the effluent upward to 15 feet and/or 150 feet horizontally. Once the water is discharged and the water level in the container goes down, the microswitch deactivates the unit until the flush is activated again. A normal operating cycle for SaniPLUS takes about 15 - 18 seconds depending upon the discharge pipe run configuration; power consumption is therefore minimal.
In addition to the toilet waste, SaniPLUS will also discharge gray wastewater from a variety of other sanitary fixtures, such as: a hand basin, a bath, a bidet and a urinal. When adding a bathtub or shower, a base will have to be constructed, made out of 2" x 6" on edge, to allow for the installation of a P-trap and some gravity flow towards the pump unit.
The wastewater from other sanitary fixtures is discharged into SaniPLUS via two 1 1/2-inch inlets, on either side of the housing. Either one or both inlets can be used as required. The discharge elbow on top of the Saniplus can be turned either to the left or to the right, depending on the discharge installation.
The SaniPLUS automatically adjust the input rate from other sanitary fixtures, always giving priority to the discharge water of the toilet. Inlet valves operated by a simple float mechanism achieve this. For example, if the bath is being emptied and the toilet is flushed simultaneously, the inrush of water from the toilet into the container slows down or stops the discharge from other fixtures for a few seconds, until the waste from the toilet has been dealt with. As the toilet water is discharged and the level in the container goes down the float valves open and the discharge from the other fixtures resumes.
The SaniPLUS is designed to provide vertical pumping up to 15 feet as well as a horizontal discharge, therefore a simple ball non-return valve is incorporated. It has now become possible to install a complete bathroom where previously this would have been impossible or where considerable capital equipment and structural work would have been necessary.
The Saniflo SaniPLUS Macerating Upflush Toilet includes the SaniPLUS macerating pump, toilet bowl, flush tank and a free soft-close toilet seat for additional comfort. This toilet includes an elongated toilet bowl in place of the standard bowl, an extension pipe to enable the macerating unit to fit out of sight behind a wall, a SaniALARM that warns if the macerator's water level becomes higher than normal, and a descaler that cleans and removes hard water deposits that can build up inside the macerator.
This SaniPLus design provides a peaceful flushing experience with vibration absorbers that reduce the macerator's 10- to 15-second operating process sound by 10dB.
The SaniPLUS has been certified to American and Canadian Standards. Macerating standard; US: CSA Certified & IAPMO (UPC) listed - ASME A112.3.4, CA: Macerating Standard CSA B45.9.
SaniPLUS Water Conservation
The water closet the SaniPLUS is connected to, uses much less water than a regular toilet, it uses 6 liters (1.6 US Gal) of water per flush.
I have a SaniPlus system for the bathroom and also have a grey water system for the kitchen in the same apartment. Both systems have been running for about 1 1/2 years. I have not had any problems so far and I am very pleased with the systems. Thank you for the good work and high quality equipment.
Installed myself. Have had it for 2 months. Used in a basement 1/2 bath. Easy to install, Works better than I thought it would. Would buy again.
Cheap compared to ripping up basement floor.
Amazing customer service. Great product. We had some unfortunate problems during shipping and we thought it would delay our project, especially given that it was during the Christmas season. This seller went above and beyond to expedite and remedy the situation and our toilet is now installed and functioning perfectly. Highly recommend buying from these guys. Thank you!!!!
I must of called a hundred times with questions, but the ladies who answer the phone are so patient and nice! Thanks so much. Finally pulled the trigger and got one of these. My plumber had it installed in a day, so like some other people said, just wish I did this sooner. Thanks again everyone who helped me out. Wonderful experience!
It's really a nicely designed product. I wish the pump weren't so visible behind the toilet, but an extension can easily hide it behind a wall, which makes it look like any other toilet. But if it's not convenient to put it behind a wall, then either you have a faceplate on the wall for access or you hope you never need to maintain it. It's low maintenance, fortunately, but you still want access without having to rip out drywall (if you get the extension).
The unit itself is pretty self explanatory. The instructions are a little unclear about specifics when it comes to plumbing, but the customer support people here were great. They have an step-by-step install manual with pictures, ask them for it.
It was a little confusing to attach the toilet, as I wasn't used to this type of toilet before, but now that I've done it once, I realize how simple it really is, and I wish I had another bathroom to put a toilet into so I could do it so much faster.
Response from upflushTOILET.com | SaniFlo Products
I was a bit skeptical about how this would work, but I decided to try it out. I LOVE it! I would give it 5 stars, but I didn't know about the extension pipe, and I would have gotten that if I had known about it before buying.